Onion rye, sliced sourdough, or challah would all be great breads for this sandwich. At Macrina, we often feature it on our pretzel knot roll, a fairly dense roll made with the addition of a little rye flour, then topped with coarse salt, poppy seeds, and sesame seeds. The combination of these flavors with the American favorite delicacy of thinly sliced peppery pastrami plus sweet caramelized onions and nutty Gruyère cheese is terrific.–Leslie Mackie

What’s the difference between pastrami and corned beef?

There are a couple differences. Corned beef is made from brisket, which comes from the lower chest of the cow; pastrami is typically made either from a lean, wide, firm shoulder cut, or a smaller and juicier section right below the ribs, although you may occasionally see pastrami made from brisket. The biggest difference is the spices used. Corned beef is, well, naked. Aside from the flavor of the brine, it doesn’t have much else added. Pastrami, on the other hand, is coated with black pepper, coriander, mustard seeds, fennel seeds, and sometimes fresh garlic.

A pastrami, caramelized onion, and Gruyère sandwich on a pretzel roll sliced in half with a sprig of thyme lying beside it on a wooden cutting board.

Pastrami Sandwich

5 / 2 votes
This pastrami, caramelized onion, and Gruyère sandwich combines peppery meat, sweet onions, and the subtle yet essential tang of cheese in this easy, satisfying meal.
David Leite
CourseMains
CuisineAmerican
Servings4 sandwiches
Calories777 kcal
Prep Time25 minutes
Cook Time1 hour 15 minutes
Total Time1 hour 45 minutes

Ingredients 

For the caramelized onions

  • 4 tablespoons (2 oz) unsalted butter
  • 2 medium yellow or Walla Walla onions, cut into 1/8-inch (3-mm) slices
  • 1 teaspoon chopped thyme leaves
  • 1/4 teaspoon crushed red pepper flakes, (optional)
  • Kosher salt to taste

For the mustard aioli

  • 1 large egg yolk
  • 1/2 teaspoon finely chopped garlic
  • 1 1/2 teaspoons fresh lemon juice
  • 1 plus 1 teaspoon Dijon-style mustard
  • 1/2 cup canola oil
  • Kosher salt to taste

For the sandwiches

  • 4 pretzel rolls or other sandwich rolls or sturdy bread
  • 2 tablespoons (1 oz) unsalted butter, at room temperature
  • 10 to 12 thin slices (14 oz) good-quality pepper-crusted pastrami*
  • 4 ounces Gruyère cheese, thinly sliced

Instructions 

Make the caramelized onions

  • In a large nonstick skillet over medium-low heat, melt the butter. Add the onions and toss to coat. Cook until the onions have softened, about 5 minutes. 
  • Add the thyme and red pepper flakes, if using, to the onions and continue to cook, stirring frequently so they brown evenly, for up to 60 minutes or more. (If the heat is too hot, the onions will burn, so slow it down and take some time to enjoy the process.) Season with salt to taste and dump the onions in a large bowl.

Make the mustard aioli

  • Whisk the egg yolk, garlic, lemon juice, and mustard in a medium bowl to thoroughly combine. Start adding the canola oil, just a few drops at a time, whisking constantly, until the mixture begins to emulsify. As it thickens, continue adding the oil in a slow stream, making sure each addition is thoroughly blended before adding more. Season to taste with salt. Cover the aioli and refrigerate until needed.

Assemble the sandwiches

  • Position a rack in the center of the oven and preheat to 350°F (176°C). Line a rimmed baking sheet with parchment paper.
  • Cut each roll in half horizontally. Butter the cut sides of the rolls and place them, cut side down, on the baking sheet. Toast the rolls in the oven for 3 to 5 minutes, until the butter is melted and the rolls are warm.
  • Flip each roll over so that the cut side is up. Spread each side with some mustard aioli. Place equal amounts pastrami on the bottom half of each roll, folding it up to only slightly overhang. Next, divvy the caramelized onions among the sandwiches, layering them on the pastrami. Place the Gruyère on the top halves of the rolls. Return the sandwiches, still open-faced, to the oven for 5 minutes, or until the cheese is melted and the pastrami is warm to the touch.
  • Sandwich the halves together and, if desired, cut on the diagonal with a serrated knife. You can take it from here. Originally published on February 17, 2013.
More from Macrina

Adapted From

More from Macrina

Buy On Amazon

Nutrition

Serving: 1 portionCalories: 777 kcalCarbohydrates: 29 gProtein: 33 gFat: 60 gSaturated Fat: 20 gMonounsaturated Fat: 27 gTrans Fat: 1 gCholesterol: 171 mgSodium: 1514 mgFiber: 3 gSugar: 3 g

Nutrition information is automatically calculated, so should only be used as an approximation.

Tried this recipe?Mention @leitesculinaria or tag #leitesculinaria!
Recipe © 2012 Leslie Mackie. Photo © 2012 Jim Henkens. All rights reserved.

Recipe Testers’ Reviews

Each of the individual elements in this sandwich is delicious enough on its own, but together, they’re heavenly, albeit rich. I used a homemade rye bread with a nice crunchy crust and a tight crumb. I didn’t add hot pepper flakes to the caramelized onion because I wanted a purely sweet flavor. The aioli had the perfect amount of garlic—enough so you could taste it in the background but not so much that it overwhelmed the other flavors in the sandwich.

These pastrami, caramelized onion and Gruyère sandwiches were surprisingly rich because of all the strong flavors—I think you could make little mini 1- or 2-bite sandwiches as a perfect hors d’oeuvre! I’ll definitely be making these again when I’m in the mood for a decadent sandwich.

This is a yummy sandwich. We made it on good rye bread and had it for supper. The size of the bread or roll makes a difference here. Our slices of bread were on the small side so we each had two overstuffed sandwiches and enjoyed them to the last bite!

I omitted the red pepper flakes in our sandwiches for the sake of the young eaters. The caramelization of the onions was easy to do and affords the cook the time to make the mustard aioli. When everything is done you can let the aioli flavors meld a little or serve it right up. A quick dinner.

We enjoyed every part of this pastrami, caramelized onion and Gruyère sandwich for lunch. We found the pretzel knot rolls at Whole Foods and they were the perfect combination of crisp outside and soft inside. I made the onions the day before to speed up my day-of assembly. The aioli (my first attempt ever) was easy to make and came together flawlessly, and, of course, how could you go wrong with pastrami and Gruyère?

My only wish was that our pretzel rolls were slightly larger—one was a little small for lunch and yet 2 sandwiches would’ve been too much. Finally, I think these sandwiches could be made in advance and wrapped up to serve later. They’d be just as good at room temp as they are right out of the oven.

What a lovely, gooey, yummy sandwich! Gruyère, peppered pastrami, and caramelized onions make the world go around as far as this tester is concerned. I loved the bite of the pepper, the richness of the Gruyère, and the sweet onions all trying to escape the toasted onion bread I used to surround it. Then add in that wonderful mustard aioli and you really did it to me. Some people would say this is just a sandwich, but me, I say this is dinner for company.




About David Leite

I count myself lucky to have received three James Beard Awards for my writing as well as for Leite’s Culinaria. My work has also appeared in The New York Times, Martha Stewart Living, Saveur, Bon Appétit, Gourmet, Food & Wine, Yankee, Los Angeles Times, Chicago Tribune, The Washington Post, and more.


Hungry For More?

Roasted Potatoes with Dill

A handful of cheap ingredients. The exact perfect temperature and timing. And a little patience, please, while spuds are elevated from simple to stellar.

1 hr 5 mins

9 Impressive Easter Lamb Recipes

Impressive lamb recipes for your Easter dinner that are guaranteed to elicit oohs and ahhs. Find your favorite new way to prepare lamb chops, shoulder, or leg of lamb.

Leave a comment

Your email address will not be published. Required fields are marked *

Recipe Rating




4 Comments

  1. 5 stars
    What a great sandwich to start the day. Would be nice if you get the pretzel knot rolls recipe, I would give it a try. Thanks 🙂

    1. Helene, we’ve requested permission to reprint that recipe, you’ll be the very first to know when we have it!

  2. Is it possible to get the pretzel knot recipe? The other parts of the ‘recipe’ are too easy, but I couldn’t figure out the bread recipe on my own. Thanks!

    1. Deanna, we received permission from the publisher to reprint the sandwich recipe, but not the pretzel knot rolls recipe. But hang in there, let me inquire again. If we can acquire the recipe, I’ll have our testers give it a twirl and then I’ll be back in touch….